2004 Hyundai Santa Fe Timing Belt Broke

From 2010 to 2021 all Hyundai Santa Fe models have timing chains and interference engines. 2004 Hyundai Santa Fe 72000 mi Visitor After replacing the timing belt by a qualified dealer two weeks later a bolt broke causing the engine to need replacement.

Valve Timing Belt Diagram Maintenance Replacement

Meaning if the belt has broken it is likely that the valves have hit the pistons and caused considerably internal damage.

2004 hyundai santa fe timing belt broke. When engine timing is not working properly issues arise such as excessive exhaust fumes shaking or jerking when gears shift and other finer symptoms that may go unnoticed. I have just had similar problem was on my way to work and car just stopped like it ran out of fuel. Our local garage took a look the engine has rockers designed to break if timing goes.

Its driving perfectly now. From 2001 to 2009 the 33L Santa Fe has a timing chain and interference engine while the 24L 27L and 35L have timing belts and interference. This will be a costly repair at minimum requiring the head to be removed and rebuiltreplaced plus other items that should be taken care of while youre in there seals water pump tensioner hoses etc.

The result is usually catastrophic engine failure. It pays to know. The car just stalled and died and had to be towed to a shop.

After looking at other web sites realised this is a common fault with 2002 santa fe. The timing belt broke on my 2004 hyundai sonata 180000 miles while driving down the highway. Replacing a timing belt on your Hyundai Santa Fe is a very difficult job.

My balance shaft belt broke which caused the timing belt to jump a tooth still waiting for a quote for repair its up to 2000 so far through hyandai. I have only owned it a week it has been service on a regular basis but the services provider wont supply me with what attcually was done when serviced. 22 He did the timing belt at 110000 km and it went at 180000 km.

Time deteriorates the belt too which is why there is a replacement interval in months. Dads santa fe broke 4 of the 8 rockers he replaced all eight. 03262006 Allstate found that there was 1 water pump failure 2 some form of drive belt failure and 3 the interference engine had parts collide within the engine leading to a fire.

In fact Im looking at these 3 vehicles. Remove the timing belt cover. The belt can LOOK perfect but break tomorrow.

1998 Jeep Cherokee 2000 2002 Honda CR-V last a 2005 Hyundai Santa Fe. A Hyundai Santa Fe Timing Belt meshes the timing of your motors camshaft with that of the pistons causing the valves to open and shut as they should. I wanted to look for a Toyota 4Runner because that vehicle is still ranked 1 in America has been for years.

When I picked up the car and started it the engine had a rough idle. The symptoms of a Hyundai car timing belt going bad are detected in the timing of the engine. Most Hyundai vehicles seem to come with a 60000 mile recommended replacement interval so Id suggest you replace the belt soon.

Its now done 135K Km. New timing belt and water pump cost 750 all in. Not so with a non-interference engine.

The Hyundai Santa Fe Timing Belt must be replaced as recommended so as to avoid motor damage. An interference engine is one that has insufficient clearance between the valves and pistons if the cam stops turning due to a broken timing belt. Do yourself a favor and replace the belt at recommended intervals.

Looking at a timing belt tells you NOTHING in most cases. Includes parts and labor 460 - 540 Important Info Definitions Valid for ZIP Code 23917. The belt which turns the engine crankshaft and camshaft must be positioned exactly during removal and installation in a position known as the Top Dead Center position.

You may want to get the crank angle sensor checked as well as my car has done two. Can I tell if my 2004 Hyundai santa fe has had its timing belt changed. I have a 2004 Santa Fe changed the timing belt at 60k that did not keep the engine from failing the other day at 109k.

If the timing belt does go out on a Hyundai. In this video I attempt to postulate a cause for the broken tensioner bolt in these vehicles. I just watched 2000 4Runner with.

Timing belt pulley etc all failed mechanic said never seen anything like that before. Remove the crankshaft pulley engine coolant pump pulley and drive belt. My father drives a 2008 Santa fe.

It ruined the engine oh well was 6 weeks from trading for new vehicle. At this time the timing marks of the camshaft sprocket and cylinder head cover should coincide with eachother and the dowel pin of the camshaftsprocket should be at the upper side. Shop replaced the timing belt and tensioners balance shaft belt water pump and crank position sensor.

The video below will also help you determine if your car has a timing belt or chain. The Hyundai engine is called an interference engine which means that when the timing belt breaks it will allow the valves to hit the pistons and you will ruin your engine. Engine Belts And Pulleys problem of the 2004 Hyundai Santa Fe 33 Failure Date.

The following procedure is specific to a.

The Timing Belt Broke On A 2003 Hyundai Santa Fe And Need To Know How To Reset It